OWNER’S MANUAL SUPPLEMENT
2002 SCRAMBLER 400 4X4
PN 9917466
IMPORTANT: This is a supplement to your owner’s manual. This information should remain with your owner’s manual at all
times.
Capacities
Gen III
Suspension and Brakes
Body Style
Front Susp. - Mac Strut
8.2 inches
Gross Vehicle Weight
Fuel Capacity
845
Rear Susp. - Progressive
Rate Swing Arm
10.5 inches
4 U.S. Gallons
32 Ounces
2 Quarts
Shock Adjustment
Front Brake
Thread Adjust
Gearcase Oil
Fixed disc, hydraulic
floating caliper
Engine Oil Capacity
Front Rack (Maximum -
Capacity)
Accessory (30 Lbs.)
Rear Brake
Auxiliary Brake
Park Brake
Hydraulic, opposed
piston caliper, rear axle
fixed disc
Rear Rack
Tongue Weight
Tow Hitch
Accessory (60 Lbs.)
30 Lbs.
Hydraulic, opposed pis-
ton caliper, rear axle,
fixed disc
Accessory
850 Lbs.
Tow Capacity
Turn Radius
Ground Clearance
Height
Hydraulic lock all wheel
60 inches
Engine & Cooling
5.5 inches
47 inches
Engine Model Number
Engine Type
Lubrication
EC38PLE-09
2 cycle, single cylinder
Oil Injection
83 x 70
Length
74.5 inches
34 inches
Seat Height
Dry Weight
Wheel Base
Width
Bore x Stroke
Displacement
Compression Ratio
Engine Cooling
Alternator Output (watts)
Carburetion
532 Lbs.
378
48.5 inches
45.5 inches
6.9:1 Effective
Liquid
Drive System
150
Drive System Type
Shift Type
PVT
VM34SS
Side Lever (F-N-R)
Not Applicable
4.36 / 1
Main Jet
240
Gear Reduction - Low
Gear Reduction - Reverse
Gear Reduction - Foward
Front Drive (ratio)
Final Drive (ratio)
Center Drive (ratio)
Drive Chain
Pilot Jet
25
Needle Jet
(0-6) 480
2.82 / 1
Air Screw
1.25
2:1
Jet Needle
6CEY6-4
13/36 76P
Not Applicable
520 O-ring
23 x 7 - 10
22 x 11 - 10
4 PSI
Ignition
CDI
Timing
23.5 @ 5000 ꢀ 2
.028 inches / .7 mm
NGK BR8ES
USFS Approved
Spark Plug Gap
Spark Plug Type
Exhaust
Front Tire
Rear Tire
Tire Pressure (front)
Tire Pressure (rear)
3 PSI
IMPORTANT: After the first tank of pre-mixed fuel has been used please verify that the oil level in the oil tank
has dropped, indicating that the oil pump is functioning properly. If the level has not dropped, see your dealer
for oil pump bleeding and repeat the pre-mix procedure.
1
|